Monitoring System Development for Deformation and State Detection of Oil sand Function Module

doi:10.22716/sckt.2019.7.2.021

All Issue

2019 Vol.7, Issue 2 Preview Page Next Page

Research Article

Monitoring System Development for Deformation and State Detection of Oil sand Function Module 오일샌드 기능 모듈의 변형 및 상태 감지를 위한 모니터링 시스템 개발: Jinwoo-Jung^1*
정진우^1*; ¹Korea KGT Consultant

¹(주)한국케이지티콘설턴트

30 June 2019. pp. 15-23

PDF

Abstract

오일샌드 플랜트 및 모듈의 부분적인 변형 또는 플랜트 전체의 변형을 모니터링하기 위한 연구로써 GPS 및 IMU를 이용하여 변형감지시스템을 구현하고 실시간으로 모니터링 할 수 있는 시스템을 개발하였다. 또한 오일샌드 플랜트 및 모듈에 부착된 센서의 상태를 모니터링하기 위한 연구로써 동작감지기를 이용하여 상태감지시스템을 구현하고 실시간으로 모니터링 할 수 있는 시스템을 개발하였다. 오일샌드 플랜트의 모듈은 지반의 장·단기 침하 및 이동 등으로 인하여 모듈 및 플랜트 전체의 구조적인 안정성 변화를 초래할 수 있다. 또한 모듈 접합부의 결합, 손상 및 외력에 의하여 오일샌드 플랜트 전체의 안정성에 심각한 영향을 초래할 수 있다. 따라서 오일샌드 플랜트와 기능모듈의 국소적 변형 또는 전체적인 변형을 실시간으로 모니터링 할 필요가 있다. 변형 감지 시스템을 구현하고 모니터링 소프트웨어를 개발하였으며 자체 테스트를 수행하여 성능을 확인하였다. 최종적으로 변형 및 상태 감지 시스템을 구현하고 의사결정지원 및 알람 모듈을 개발하였으며, 자체 테스트를 수행한 결과, 상태 이상을 오류 없이 감지하였으며, 상태 이상 발생시 알람화면을 출력하는 등 성능을 확인할 수 있었다.

This research is intended to monitor partial deformation of the oil sand plant and module or deformation of the entire plant. GPS and IMU are used to implement a deformation detection system and develop a system that can monitor in real time. In addition, this research is intended to monitor partial deformation of the oil sand plant and module or deformation of the entire plant. GPS and IMU are used to implement a deformation detection system and develop a system that can monitor in real time. The module of the oil sand plant may cause structural stability change of the entire module and the plant due to long and short settlement and movement of the ground. Also, the stability of the entire oil sand plant may be seriously affected by the joining, damage, and external force of the module joints. Therefore, it is necessary to monitor in real time the local deformation or the overall deformation of the oil sand plant and the functional module. Implemented the deformation and state detection system, developed the decision support and alarm module. The deformation detection system was implemented, monitoring software was developed, and performance was verified by performing self test. As a result of performing the test, it was able to check the status without error and output the alarm screen when the status error occurred.

Keywords

Deformation and state detection system

Oil sand plant

Monitoring System

References

Ahmad, N., Ghazilla, R. A. R., Khairi, N. M., & Kasi, V. "Reviews on various inertial measurement unit (IMU) sensor applications." International Journal of Signal Processing Systems, vol. 1, no. 2, pp.256-262, 201310.12720/ijsps.1.2.256-262
Celebi, Mehmet, and Ahmet Sanli. "GPS in pioneering dynamic monitoring of long-period structures." Earthquake Spectra, vol.18, no.1, pp.47-61, 200210.1193/1.1461375
Cohn, Gabe, et al. "An ultra-low-power human body motion sensor using static electric field sensing." Proceedings of the 2012 ACM Conference on Ubiquitous Computing. ACM, 2012.10.1145/2370216.2370233
GW Roberts, E Cosser, X Meng, A Dodson , “"High Frequency Deflection Monitoring of Bridges by GPS,”" Journal of Global Positioning Systems, vol 3, no 1-2, pp.226-231, 2008.10.5081/jgps.3.1.226
Kain, James E., and Charles Yates. "Airborne imaging system using global positioning system (GPS) and inertial measurement unit (IMU) data." U.S. Patent No. 5,894,323., 13 Apr. 1999.
Kersey, A.D., Davis, M.A., Patrick, H.J. LeBlanc, M., Koo, K.P., Askins, C.G., Putnam, M.A.,& Friebele, E.J., Fiber grating sensors, Journal of Lightwave Technology, vol. 15, no 8, pp.1442-1463, 1997.10.1109/50.618377
Koo, Gunhee, et al. "Development of a high precision displacement measurement system by fusing a low cost RTK-GPS sensor and a force feedback accelerometer for infrastructure monitoring." Sensors vol. 17, no.12, 201710.3390/s1712274529182563PMC5751616
Li, Xiaojing and Ge, Linlin and Peng, Gang-Ding and Rizos, Chris and Tamura, Yukio and Yoshida, Akihito, Seismic Response of a Tower as Measured by an Integrated RTK-GPS System, 2004
Lydon, Myra, et al. "Development of a bridge weigh-in-motion sensor: performance comparison using fiber optic and electric resistance strain sensor systems." IEEE Sensors Journal, vol. 14, no. 12, pp.4284-4296, 2014.10.1109/JSEN.2014.2332874
Yi, TingHua, HongNan Li, and Ming Gu. "Recent research and applications of GPS based technology for bridge health monitoring." Science China Technological Sciences, vol. 53, no. 10, pp.2597-2610, 201010.1007/s11431-010-4076-3

Information

Publisher :The Society of Convergence Knowledge
Publisher(Ko) :융복합지식학회
Journal Title :The Society of Convergence Knowledge Transactions
Journal Title(Ko) :융복합지식학회논문지
Volume : 7
No :2
Pages :15-23
DOI :https://doi.org/10.22716/sckt.2019.7.2.021

[1] Ahmad, N., Ghazilla, R. A. R., Khairi, N. M., & Kasi, V. "Reviews on various inertial measurement unit (IMU) sensor applications." International Journal of Signal Processing Systems, vol. 1, no. 2, pp.256-262, 201310.12720/ijsps.1.2.256-262

[2] Celebi, Mehmet, and Ahmet Sanli. "GPS in pioneering dynamic monitoring of long-period structures." Earthquake Spectra, vol.18, no.1, pp.47-61, 200210.1193/1.1461375

[3] Cohn, Gabe, et al. "An ultra-low-power human body motion sensor using static electric field sensing." Proceedings of the 2012 ACM Conference on Ubiquitous Computing. ACM, 2012.10.1145/2370216.2370233

[4] GW Roberts, E Cosser, X Meng, A Dodson , “"High Frequency Deflection Monitoring of Bridges by GPS,”" Journal of Global Positioning Systems, vol 3, no 1-2, pp.226-231, 2008.10.5081/jgps.3.1.226

[5] Kain, James E., and Charles Yates. "Airborne imaging system using global positioning system (GPS) and inertial measurement unit (IMU) data." U.S. Patent No. 5,894,323., 13 Apr. 1999.

[6] Kersey, A.D., Davis, M.A., Patrick, H.J. LeBlanc, M., Koo, K.P., Askins, C.G., Putnam, M.A.,& Friebele, E.J., Fiber grating sensors, Journal of Lightwave Technology, vol. 15, no 8, pp.1442-1463, 1997.10.1109/50.618377

[7] Koo, Gunhee, et al. "Development of a high precision displacement measurement system by fusing a low cost RTK-GPS sensor and a force feedback accelerometer for infrastructure monitoring." Sensors vol. 17, no.12, 201710.3390/s1712274529182563PMC5751616

[8] Li, Xiaojing and Ge, Linlin and Peng, Gang-Ding and Rizos, Chris and Tamura, Yukio and Yoshida, Akihito, Seismic Response of a Tower as Measured by an Integrated RTK-GPS System, 2004

[9] Lydon, Myra, et al. "Development of a bridge weigh-in-motion sensor: performance comparison using fiber optic and electric resistance strain sensor systems." IEEE Sensors Journal, vol. 14, no. 12, pp.4284-4296, 2014.10.1109/JSEN.2014.2332874

[10] Yi, TingHua, HongNan Li, and Ming Gu. "Recent research and applications of GPS based technology for bridge health monitoring." Science China Technological Sciences, vol. 53, no. 10, pp.2597-2610, 201010.1007/s11431-010-4076-3

The Society of Convergence Knowledge TransactionsISSN:2287-8920(Print)융복합지식학회

All Issue